A pilot-scale forward osmosis membrane system for concentrating low-strength municipal wastewater: performance and implications

Citations Over TimeTop 10% of 2016 papers

Abstract

Recovery of nutrients and energy from municipal wastewater has attracted much attention in recent years; however, its efficiency is significantly limited by the low-strength properties of municipal wastewater. Herein, we report a pilot-scale forward osmosis (FO) system using a spiral-wound membrane module to concentrate real municipal wastewater. Under active layer facing feed solution mode, the critical concentration factor (CCF) of this FO system was determined to be 8 with 0.5 M NaCl as draw solution. During long-term operation at a concentration factor of 5, (99.8 ± 0.6)% of chemical oxygen demand and (99.7 ± 0.5)% of total phosphorus rejection rates could be achieved at a flux of 6 L/(m(2) h) on average. In comparison, only (48.1 ± 10.5)% and (67.8 ± 7.3)% rejection of ammonium and total nitrogen were observed. Cake enhanced concentration polarization is a major contributor to the decrease of water fluxes. The fouling also led to the occurrence of a cake reduced concentration polarization effect, improving ammonium rejection rate with the increase of operation time in each cycle. This work demonstrates the applicability of using FO process for wastewater concentrating and also limitations in ammonium recovery that need further improvement in future.

Related Papers

• → Influence of concentrative and dilutive internal concentration polarization on flux behavior in forward osmosis(2006)1,314 cited
• → Modeling water flux in forward osmosis: Implications for improved membrane design(2007)380 cited
• → Reverse Osmosis and Forward Osmosis for the Concentration of Fruit Juices(2017)20 cited
• Research advances in forward osmosis membrane separation(2011)
• Obrada voda naprednom osmozom(2016)